Click here to subscribe FREE to Ray Hanania's Columns
Mile Long Bridge beam delivery continues in May on Central Tri-State (I-294) project
Beam deliveries escorted by State Police will impact travel on I-90, I-290, I-355, I-80, I-57 and I-294
Transport and delivery of bridge beams will continue in May for the Illinois Tollway’s new northbound Mile Long Bridge on the Central Tri-State Tollway (I-294) and overnight lane closures will be scheduled as needed on I-294 to accommodate beam placement.
About 42 concrete beams from a Wisconsin manufacturing plant and material for 30 steel beams from an Indiana manufacturing plant are expected to be delivered in May. Transport trucks with the concrete beams will be escorted by Illinois State Police, as needed, and will be traveling at a low rate of speed between hours of 4:30 a.m. and noon on weekdays. The steel beams do not require a State Police escort and the times of deliveries will vary. All delivery schedules are weather dependent.
Concrete beam delivery will continue in mid-May with beams measuring up to 6 feet tall and up to 137 feet long,transported from the Wisconsin border traveling eastbound on the Jane Addams Memorial Tollway (I-90) to I-290, then south to the Veterans Memorial Tollway (I-355), south to I-80 and then east to northbound I-294. These beams will be erected from northbound I-294 overnight. To accommodate the beam installation, overnight lane closures will be scheduled for three nights on northbound I-294 between the 83rd Street Toll Plaza and the Mile Long Bridge, with a single lane closure expected to begin at 6 p.m., followed by a double lane closure at 8 p.m. between Archer Avenue and the Mile Long Bridge. All lanes are scheduled reopen by 5 a.m. the following morning on weekdays and by 9 a.m. the following morning on Saturdays.
In addition, some concrete beams will be transported eastbound on I-90 to I-290, then south on I-355, east on I-55, south on I-294, exiting at 75th Street and continuing to the job site on Santa Fe Drive.
Steel beam delivery will continue in May with portions of steel beams measuring up to 10 feet tall and up to 130 feet long transported from the Indiana border traveling northbound on the Tri-State Tollway (I-294/I-80) to I-55 north to U.S. Route 45 south to exit at the job site at West Lawndale Avenue Island on the east side of the bridge.
Delivery of more than 430 concrete beams and steel beams to the construction site near Countryside, Hodgkins, Willow Springs and Justice is more than halfway complete and will continue over the coming months.
This work is part of the Illinois Tollway’s project to reconstruct the Mile Long Bridge that carries traffic over two major railroads, the Des Plaines River, the Chicago Sanitary & Ship Canal and the Illinois & Michigan Canal and local roads, and over several major distribution centers.
The Mile Long Bridge is one of the first major construction segments for the Central Tri-State Tollway (I-294) Project. Currently, up to 150,000 vehicles travel across the Mile Long Bridge daily. Construction is scheduled to be complete by the end of 2023.
The project includes building two, new side-by-side 4,800-foot-long bridge structures to increase capacity from four lanes to five lanes in each direction as part of the reconstruction and widening of the Central Tri-State Tollway between Balmoral Avenue and 95th Street. In addition, the inside shoulders on the bridge will be built to serve as Flex Lanes to provide for transit, assist emergency vehicles and serve as an alternate lane to reduce traffic congestion when warranted.
The design of the new bridge structures took into consideration the sensitive aquatic ecosystem, navigable waterways and existing railroad and roadway operations underneath the structure. Each of the new structures will have fewer piers to reduce the environmental impact on the waterways and industrial areas below. Each bridge will have 27 spans supported by 26 piers, compared to the existing structures with 106 piers. The spans will be made up of a total of nearly 600 steel or concrete beams of various lengths.
The Illinois Tollway is coordinating work on the Mile Long Bridge Project with the Village of Hodgkins, Village of Countryside, Village of Willow Springs, Village of Justice, Cook County, the Forest Preserve District of Cook County, Illinois Environmental Protection Agency, U.S. Army Corps of Engineers, U.S. Department of Fish and Wildlife, Illinois Department of Natural Resources (IDNR), IDNR Office of Water Resources and the Illinois Nature Preserve Commission, as well as numerous businesses located near the Mile Long Bridge.
The work is part of the Illinois Tollway’s 15-year, $14 billion capital program, Move Illinois: The Illinois Tollway Driving the Future.
Construction information about the Mile Long Bridge Project is available in the “Projects by Roadway” section in the Explore Projects section on the Tollway’s website at illinoistollway.com.
Work Zone Safety
Construction zone speed limits are in effect in all construction zones 24/7 and drivers should continue to watch for changing traffic patterns and use caution, especially when workers are present. On I-294, a 45 mph work zone speed limit is in effect throughout the construction season.
The Illinois Tollway reminds motorists that the “Move Over Law” requires motorists to change lanes or to slow down and proceed with caution when passing any vehicle on the side of the road with hazard lights activated. If you see flashing lights ahead, please move over or slow down.
Illinois State Police have zero tolerance for drivers speeding in work zones or failure to comply with the Move Over Law. The minimum penalty for speeding in a work zone is $250 and can include up to a $25,000 fine and a 14-year jail sentence for hitting a roadway worker. Penalties for failure to slow down or move over for a vehicle on the shoulder with flashing lights includes up to a $10,000 fine, 2-year suspension of driving privileges and jail time, in extreme cases.
About Move Illinois
The Illinois Tollway’s 15-year, $14 billion capital program, Move Illinois: The Illinois Tollway Driving the Future, is improving mobility, relieving congestion, reducing pollution, creating as many as 120,000 jobs and linking economies throughout the region. The first eight years of Move Illinois is on schedule and within budget, delivering the rebuilt and widened Jane Addams Memorial Tollway (I-90) as a state-of-the-art 21st century corridor and opening a new interchange connecting the Tri-State Tollway (I-294) to I-57. Progress continues on projects addressing the remaining needs of the existing Tollway system, delivering the Elgin O’Hare Western Access Project and planning for emerging projects, including reconstruction of the Central Tri-State Tollway (I-294).
About the Illinois Tollway
The Illinois Tollway is a user-fee system that receives no state or federal funds for maintenance and operations. The agency maintains and operates 294 miles of roadways in 12 counties in Northern Illinois, including the Reagan Memorial Tollway (I-88), the Veterans Memorial Tollway (I-355), the Jane Addams Memorial Tollway (I-90), the Tri-State Tollway (I-94/I-294/I-80) and the Illinois Route 390 Tollway.
Click here to subscribe FREE to Ray Hanania's Columns
His award winning columns can be found at www.HANANIA.COM Subscribe FREE today
Hanania also writes about Middle East issues for the Arab News, and The Arab Daily News criticizing government policies in the Israeli-Palestinian conflict.
Hanania was named "Best Ethnic American Columnist" by the New America Media in November 2007, and is the 2009 recipient of the SPJ National Sigma Delta Chi Award for column writing.
Email Ray Hanania at [email protected].
Follow RayHanania at Twitter
- Cook County Treasurer Pappas and Alliance of Polish Clubs President Mirowska-Kopec recognize Polish population by honoring local leaders ahead of Polish Constitution Day - May 1, 2026
- Leving Team Reunited Grandparents with Grandchildren - May 1, 2026
- OFPD extinguishes garage fire in Orland Park, no injuries reported - May 1, 2026
Comment on “Mile Long Bridge beam delivery continues in May on Central Tri-State (I-294) project”